The Building of Scaffolding Tubes is the Beginning of the Project

Scaffolding refers to the construction site for workers operation and solve the vertical and horizontal transportation and erection of all kinds of support.

Architecture of the generic term, refers to the construction site in exterior, interior, or higher storey height can’t construction directly. Mainly for construction personnel working up and down or peripheral safety maintenance and high altitude installation components etc, to put it bluntly, is which the scaffold materials usually are: bamboo, wood, steel or synthetic materials.

Pre-galvanized steel pipes5.jpg

 

Some works also use scaffolding tubes when the template is used, in addition in the advertising industry, municipal, transportation, mining and other departments is also widely used. ADTO scaffolding rental scaffolding, scaffolding construction good helper, is your right choice.

After the removal of scaffolding square tube should be according to the first open principle, according to the following procedures: from cross-border open at the top of the armrest and baluster at first, and then dismantle scaffold board and escalators, and unload horizontal rod reinforcing rod and bracing.

Since the top edge began to remove cross sustaining, synchronous remove the top bracing rod with the wall top door frame. Continue to phase synchronization under the demolition of the second step the door frame and accessories. Scaffold free cantilever height shall not exceed three steps, or shall provide temporary Rachel.

tube coupler scaffold

To remove the continuous synchronization. For even the wall rod, scissors, long horizontal, must be removed in the scaffold to relevant across the door frame, before dismantling. Demolition of sweeping bar, the bottom door frame and sealing bar. Demolition of base plate and pad.

What Problems Shall be Paid Attention When Using the Scaffolding Tube

Scaffolding pipe can provide construction personnel and the side of the road the pedestrian safety net to maintain security and periphery and high altitude installation, etc. Under the scaffolding tube manufacturers as an introduction to using shelves tube what problem should note.

scaffold-tube

1, to ensure that the frame tube surface cleaning, such as regularly remove accumulated in the pipe scaffolding dangerous parts of the materials, brick, concrete block and sundry;   And on the shelves on the tube material should have certain limit, can’t overload piled up. Otherwise it will cause the scaffolding tube damage, or scaffolding pipe in use there are a lot of potential safety hazard, increases the risk of construction.

2, when we use tube scaffolding, to observe the frame tube structure of the whole or local whether there is any deviation, especially the frame tube of each joint is to loosen deflection phenomenon, such as they should be should be timely maintenance. Especially before use, check more carefully, if wait until there is a problem to repair, will not help.

3, after completing the whole frame tube, and check the net twine federated eye network root bundle loosening and mat bamboo basketry and covered with bamboo basketry colligation point for hamstring off wait for a phenomenon, if found fracture, loose, etc., should be timely change. Otherwise when construction personnel in high altitude extremely easy falling off the scaffolding tube, causing serious accidents.

More ideas, pls contact us freely

Michael

Tel: +86-731-82810123

Mobile: +86-158 0250 6697

Email: michael6615@hotmail.com

 

China Scaffolding Application

In the old times, the bamboo was introduced into the building industry in Hong Kong immediately after colonization in the 1800s, notably The Great Wall of China, were built using bamboo.

For my houses in the countyside, they were built in  1990 & 2000, the supporting system were also the bamboo scaffoldings.

As the time going by, more and more people realize the importance of safety in the building sites. Nowadays, the tubular scaffolding is widely used in the residential buildings as below pictures.

adto-tube-scaffolding-for-sale

Because its costs is lower than modular scaffoldings like kwikstage scaffolding, Ringlock, although it is heavily laboring works.

For the big commercial or government projects, the ringlock is used, our honored projects is the  Changsha Maglev Express

Following the step of economic developmemt, it is believed that, more and more modular scaffolding will be presented in the construction sites, not only industrial sites but also civilling, residential projects.

Do You Know the Usage Requirements of Scaffolding Tube ?

Scaffolding accessories at the time of use must be set-up, according to the regulations of the project and the scope of the use of safe to must not exceed the design load, and during the construction of security. Members also have hands feet at the same time, construction, materials and tools, when structures, no specific provisions, must be carried out in accordance with the safety scope to set up.

scaffolding tube

Continue reading